Jatropha Oil Research
A review of Jatropha curcas: an oil plant of unfulfilled promise: Jatropha curcas is a multipurpose plant with many attributes and considerable potential. It is a tropical plant that can be grown in low to high rainfall areas and can be used to reclaim land, as a hedge and/or as a commercial crop. Thus, growing it could provide employment, improve the environment and enhance the quality of rural life. The establishment, management and productivity of jatropha under various climatic conditions are not fully documented. This is discussed and the gaps in the knowledge elucidated, especially its fertilizer requirements. The plant produces many useful products, especially the seed, from which oil can be extracted; this oil has similar properties to palm oil. The costs and returns of growing the plant and producing the plant oil are discussed and tabulated. Because it can be used in place of kerosene and diesel and as a substitute for fuelwood, it has been promoted to make rural areas self sufficient in fuels for cooking, lighting and motive power. This strategy is examined and found not viable. Oil for soap making is the most profitable use. It is concluded that all markets for jatropha products should be investigated. If the full potential of the plant is to be realized, much more research is required into the growing and management of Jatropha curcas and more information is needed on the actual and potential markets for all its products.
Performance of jatropha oil blends in a diesel engine: Results are presented on tests on a single-cylinder direct-injection engine operating on diesel fuel, jatropha oil, and blends of diesel and jatropha oil in proportions of 97.4%/2.6%; 80%/20%; and 50%/50% by volume. The results covered a range of operating loads on the engine. Values are given for the chemical and physical properties of the fuels, brake specific fuel consumption, brake power, brake thermal efficiency, engine torque, and the concentrations of carbon monoxide, carbon dioxide and oxygen in the exhaust gases. Carbon dioxide emissions were similar for all fuels, the 97.4% diesel/2.6% jatropha fuel blend was observed to be the lower net contributor to the atmospheric level. The trend of carbon monoxide emissions was similar for the fuels but diesel fuel showed slightly lower emissions to the atmosphere. The test showed that jatropha oil could be conveniently used as a diesel substitute in a diesel engine. The test further showed increases in brake thermal efficiency, brake power and reduction of specific fuel consumption for jatropha oil and its blends with diesel generally, but the most significant conclusion from the study is that the 97.4% diesel/2.6% jatropha fuel blend produced maximum values of the brake power and brake thermal efficiency as well as minimum values of the specific fuel consumption. The 97.4%/2.6% fuel blend yielded the highest cetane number and even better engine performance than the diesel fuel suggesting that jatropha oil can be used as an ignition-accelerator additive for diesel fuel.
Lipase catalyzed preparation of biodiesel from Jatropha oil in a solvent free system: The monoethyl esters of the long chain fatty acids (biodiesel) were prepared by alcoholysis of Jatropha oil, a non-edible oil, by a lipase. The process optimization consisted of (a) screening of various commercial lipase preparations, (b) pH tuning, (c) immobilization, (d) varying water content in the reaction media, (e) varying amount of enzyme used, and (f) varying temperature of the reaction. The best yield 98% (w/w) was obtained by using Pseudomonas cepacia lipase immobilized on celite at 50 °C in the presence of 4–5% (w/w) water in 8 h. It was found that yields were not affected if analytical grade alcohol was replaced by commercial grade alcohol. This biocatalyst could be used four times without loss of any activity.
A New Tumor Promoter from the Seed Oil of Jatropha curcas L.: A new type of phorbol ester, which has a macrocyclic dicarboxylic acid diester structure, was isolated from the seed oil of Jatropha curcas L. (Euphorbiaceae). Based on the results of spectroscopic analyses of the compound and its chemical degradation products, its structure is proposed to be an intramolecular 13,16-diester of 12-deoxy-16-hydroxyphorbol, 12-deoxy-16-hydroxyphorbol-4'-[12',14'-butadienyl]-6'-[16',18',20'-nonatrienyl]-bicyclo[3.1.0]hexane-(13-O)-2'-[carboxylate]-(16-O)-3'-[8'-butenoic-10']ate (DHPB). DHPB showed slightly weaker biological and biochemical activities than 12-O-tetradecanoylphorbol-13-acetate (TPA). DHPB induced ornithine decarboxylase in mouse skin (2.8 nmol CO2/30 min/mg protein/34 nmol application), inhibited the specific binding of [3H]-12-O-tetradecanoylphorbol-13-acetate to phorbol ester receptors (50% effective dose, 17.0 nM), and activated protein kinase C in vitro (50% effective dose, 36.0 nM). Also, a weak tumor-promoting activity of DHPB was found in a two-stage carcinogenesis experiment on mouse skin. One week after initiation of mice with 100 µg of 7,12-dimethylbenz(a)anthracene, topical application, twice a week, of 2 µg of DHPB until week 17, followed by application of 5 µg of DHPB until week 30 at the same rate, resulted in 46.7% incidence of tumors by week 30. The groups treated with 7,12-dimethylbenz(a)anthracene alone or DHPB alone did not produce significant numbers of tumors. These results indicate that the new phorbol ester, DHPB, is a tumor promoter with weaker activity than 12-O-tetradecanoylphorbol-13-acetate.
Studies on antidiarrhoeal activity of Jatropha curcus root extract in albino mice: Use of Jatropha curcus L. roots in the treatment of diarrhoea is a common ethnobotanical practice in Konkan, a part of the Western coastal area of India. Roots of this species were undertaken for pharmacognostic studies and evaluation of antidiarrhoeal activity in albino mice. Successive solvent extraction was carried out using petroleum ether (60–80°C) and methanol. The methanol extract showed activity against castor oil induced diarrhoea and intraluminal accumulation of fluid. It also reduced gastrointestinal motility after charcoal meal administration in albino mice. The results indicate that action of J. curcus root methanol extract could be through a combination of inhibition of elevated prostaglandin biosynthesis and reduced propulsive movement of the small intestine.
Evaluation and bioinduction of energy components of Jatropha curcas: Jatropha curcas is a multipurpose species with many attributes and considerable potential. The oil from the seeds is potentially the most valuable end product. Nearly 40% of the land area in India is wasteland. However, a large number of latex bearing and oil yielding plants can grow under such unfavorable agroclimatic conditions. J. curcas, a Euphorbiaceae grows well under such adverse climatic conditions because of its low moisture demands, fertility requirements, and tolerance to high temperatures. The seed contains 19.0% oil, 4.7% polyphenol, and 3.9% hydrocarbon. This semi-drying oil could be an efficient substitute for diesel fuel. The gross heat value for the seed (0% moisture content) was 4980.3 cal/g (20.85 MJ/kg), oil was 9036.1 cal/g (37.83 MJ/kg), and hydrocarbon was 9704.4 cal/g (40.63 MJ/kg). The oil fraction consists of both saturated fatty acids, palmitic acid (14.1%), stearic acid (6.7%) and unsaturated fatty acids, oleic acid (47.0%), and linoleic acid (31.6%). Treatment of plants with growth regulators significantly influenced the production of hydrocarbons. Among the treatments, ethephon and morphactin induced the maximum production of hydrocarbon with 5.0% and 5.4%, respectively.